[help] - ATV Riders Forums - Honda, Yamaha, Suzuki, Kawasaki, Polaris, CanAm, Arctic Cat, Kymco ATVs

Pages:1

help
(Click here to view the original thread with full colors/images)

Posted by: bmxican345

i was at the virginia nationals last weekend and my ltr encountered a little bit of a problem.

it is VERY hard starting (via electric start, it will pop start though), and will not idle

I did fix the idle problem but all i did was crank up the idle speed a half a turn.

so far i have done the following:
changed the fuel filter
blown out and cleaned the fuel pressure regulator
cleaned the injector as best i could
cleaned the throttle body spottless
cleaned the idle circuit
checked and cleaned all the connections to every piece of electronics that have to do with the fuel system

when i try to start it with the electric start it will just crank and crank and crank and not start at all, unless i pump the throttle some to find a spot where the cranking gets faster, then it seems to spring to life, but thats like a a 1/100 chance.

the only way to start it is to pop start it and for a about 10 seconds after the start it runs a little "rough" until it seems to clean itself out.

any suggestions?

Posted by: ltrracer

Its your valves man, they are tight, pop the top on the motor and adjust those bad boys ASAP

Posted by: bmxican345

yep thats what i was gonna do today haha ill let you know what happens

Posted by: ltrracer

k cool man, let me know how they looked

Posted by: bmxican345

yeah i had the shop manual out and the specs for the intake valve clearance is from .1 - .2 mm, the smallest feeler i have is a .127 mm and that wouldnt even fit in there so as soon as i get new shims i'll but them in asap

Posted by: bmxican345

so i reshimmed the valves, didnt start, and i troubleshot the whole ignition system top to bottom and bottome to top, i troubleshot the whole FI system as well im currently on the injector as my last thing does anybody have any other suggestions?

Posted by: jherbie28

as stupid as it sounds, on the ltr there is a tip over switch behind the batwing thing that mounts the electronics. it has a pendulem(sp) type thing in there and can get stuck. this will allow the bike to crank and crank and crank all day long but not fire. take it off shake it and make sure it moves freely. like i said as stupid as this is it could be your problem. good luck

Posted by: bmxican345

yeah i've been through all that already i even checked the resistance in it, it all works fine. i did get it started last night though after cleeaning EVERYTHING. it was still a little bit hard starting but once it was warmed up it started right up so im just gonna see how it acts at the track tomarrow

Posted by: hondaracer31

Might be your battery getting weak. I had to replace mine at 6 months old. Now I keep a Battery Tender on it when I'm not riding.

Posted by: bmxican345

yeah it was cranking a little bit slow, i did charge it while i was tearing it down so it was a fresh charge when i tried it again so it cranked alot faster but it still had the same starting "characteristics" before i tore it down but idk.. im riding this weekend then ill look at it again before the next district race

Posted by: hondaracer31

The more I think about this the more I think you need to do a compression check. I've seen these symptoms before and it needed a new cylinder.

Posted by: 05Z400rdr

Also check your TPS (Throttle Position Sensor).

Landon

Posted by: bmxican345

the TPS is fine or else it would be totally non-ridable because it wouldnt respond to any throttle input. and yes after this weekends race (if i make it all the way through) im gonna do a compression test because today wen i was cleaning it i forgot to take it out of 1st to roll it back into the garage, i was hardly even pushing it and i cranked it twice sooooo thats proably it.

Posted by: bmxican345

well, my uncle donated his ltr to me for 2 weeks, so i pulled all my a arms shocks, etc. and put them on his and im sendin the motor out to yosh with a new cylinder. last time my motor was rebuilt by yosh was in jan 07 so it needs it anyway. and word is they have been gettin 6 more ponies out of them since then so ill be in luck haha